Maintenance matters during the break-in period of newly purchased garbage trucks

Sanitation garbage trucks in the break-in period of the correct operating procedures: the vehicle's break-in period generally refers to 3000-5000 kilometers (specific reference to the manual), in this section of the break-in period, the vehicle's speed is best to keep below 2,000 revolutions, the vehicle's hourly speed should be maintained at less than 80 kilometers per hour.

Try to warm up the car every time you start the vehicle, the general warm-up time is 30 seconds, you can also let the vehicle idle for 20 seconds instead of warming up the car in place, which is better.

Don't overload, speed, or mishandle the dump truck when loading or unloading it during the break-in period, and follow the instructions or methods taught by the manufacturer.

These are the operating matters of the sanitation garbage truck during the break-in period, and the following is the maintenance of the vehicle in stages during the break-in period:

1.100 kilometers: the friction brake pads have not yet reached 100% braking effect, and tire friction is not enough, therefore, when braking, it is necessary to use more force than normal, in addition, in terms of inspection and maintenance, should be tightened exposed bolts and nuts, add fuel, oil, replenishment of coolant, check the transmission, front and rear drive axles, driveshafts, wheels and tires of the air pressure. Check the light meter, battery, and braking capacity of the braking system.

2, 100-500 km: tire adhesion has not yet reached the best effect, should try to avoid emergency braking. In addition, in terms of inspection and maintenance, at this stage, engine oil should be changed and the oil pan should be cleaned; oil filter element should be replaced and the front and rear wheel nuts should be tightened.

3, 500-2500 kilometers: drivers and friends should drive gently, with a speed of no more than 100 kilometers per hour and a speed of no more than 2,500 rpm.

4, 2500-3500 kilometers: when the water temperature reaches the operating temperature, you can increase the speed to the maximum speed or maximum engine speed, check and adjust the clutch pedal.

After a routine maintenance at 3000 kilometers, the coordination between all moving parts in the vehicle is improved, resulting in smooth operation and optimal performance.

The above points are the sanitation garbage truck in the break-in period of maintenance matters, these maintenance is very important, because it is in order to make the new vehicle mechanical system to maintain the best state and extend its service life, drivers and friends must not be ignored.